隧道救援站通风网络优化设计及人员疏散研究*

为确定铁路隧道救援站最佳通风结构，对烟道布置提出合理建议，采用计算流体力学（CFD）的方法，对铁路隧道救援站通风网络进行优化设计。同时，采用模拟计算的方法对救援站人员疏散进行模拟分析，确定救援横通道布置及防护门开度设置的合理性。研究结果表明:在同等通风参数工况设置下，采用多节点排烟竖井结构后各救援横通道流量分配更均匀，救援站压力平衡性更好，通风效率可提升15%；通过疏散模拟证实，在长560 m的紧急救援站范围内设置10条疏散横通道，横通道设1.7 m宽的逃生门能够满足疏散要求。     

深部煤层钻屑粒度随钻进深度分布规律

为了研究煤层钻屑粒度随钻进深度分布规律，选取具有冲击危险性的平煤八矿己15煤作为研究对象，采取钻屑量测试和孔口瓦斯浓度监测，通过筛分实验煤样并应用Rosin Rammler分布模型，探究了钻屑粒度和钻屑量大小随孔深变化关系，分析不同点钻屑粒度分布特征。结果表明:小于0.075 mm钻屑粒度分布随孔深变化与钻屑量变化规律相吻合；不同钻孔随深度变化分别对应不同Rosin Rammler分布函数，随着应力过渡越平缓，粒径分布宽度系数n值越小，煤体应力越大粒径相关系数D越大；不同范围钻屑粒度占比大小也会影响钻屑量大小；在钻屑量较大时，孔口瓦斯体积分数会出现增高现象。通过对钻屑粒度分布规律分析，更好地了解深部煤体应力分布，有助于冲击危险的预警。     

中国南海高温高压井钻完井损失工时事件统计分析

为研究我国南海高温高压井钻完井、测试损失工时事件规律，对2009—2018年中国南海高温高压探井钻井日志进行分析，汇总501起海上高温高压井钻完井损失工时事件，并将其划分为复杂情况及事故停工、自然停工、修理停工3大类进行研究。结果表明:复杂情况及事故停工事件数与年份无明显关联，但与地质资料准确度关系密切，修理停工事件数随年份呈现震荡下降趋势；复杂情况及事故停工总损失工时最多，其中卡钻损失工时占比最高；修理停工总损失工时最少，其中钻井设备故障损失工时占比最高；灾难天气、洋流或地质活动是造成损失工时最多的原因，不安全行为是单起事件平均损失工时最多的原因，设备老化是修理停工最主要原因。研究结果可为后续高温高压井钻完井非生产时间成本估计模型提供数据基础。     

Recent application of Computational Fluid Dynamics (CFD) in process safety and loss prevention: A review

In recent years, significant progress has been made to ensure that process industries are among the safest workplaces in the world. However, with the increasing complexity of existing technologies and new problems brought about by emerging technologies, a strong need still exists to study the fundamentals of process safety and predict possible scenarios. This is attained by conducting the corresponding consequence modeling and risk assessments. As a result of the continuous advancement of Computational Fluid Dynamics (CFD) tools and exponentially increased computation capabilities along with better understandings of the underlying physics, CFD simulations have been applied widely in the areas of process safety and loss prevention to gain new insights, improve existing models, and assess new hazardous scenarios. In this review, 126 papers from 2010 to 2020 have been included in order to systematically categorize and summarize recent applications of CFD for fires, explosions, dispersions of flammable and toxic materials from accidental releases, incident investigations and reconstructions, and other areas of process safety. The advantages of CFD modeling are discussed and the future of CFD applications in this research area is outlined.     

Numerical simulation of small-scale pool fires of LNG

Liquefied natural gas (LNG) has been largely indicated as a promising alternative solution for the transportation and storage of natural gas. In the case of accidental release on the ground, a pool fire scenario may occur. Despite the relevance of this accident, due to its likelihood and potential to trigger domino effects, accurate analyses addressing the characterization of pool fires of LNG are still missing.In this work, the fire dynamic simulator (FDS) has been adopted for the evaluation of the effects of the released amount of fuel and its composition (methane, ethane, and propane), on the thermal and chemical properties of small-scale LNG pool fire. More specifically, the heat release rate, the burning rate, the flame height, and thermal radiation, at different initial conditions, have been evaluated for pool having diameter smaller than 10 m. Safety distances have been calculated for all the investigated conditions, as well.Results have also been compared with data and correlations retrieved from the current literature. The equation of Thomas seems to work properly for the definition of the height over diameter ratio of the LNG pool fire for all the mixture and the investigated diameters.The addition of ethane and propane significantly affects the obtained results, especially in terms of radiative thermal radiation peaks, thus indicating the inadequacy of the commonly adopted assumption of pure methane as single, surrogate species for the LNG mixture.     

臭氧氧化处理页岩气钻井废水的机理与动力学

采用臭氧氧化法处理页岩气钻井废水经混凝沉淀后的出水(COD=759.63 mg/L),重点研究了废水中有机污染物的去除机理与反应动力学。实验结果表明:在废水pH为11.2、臭氧通入量为8 mg/min、反应时间为50 min的最佳工艺条件下,废水的COD去除率为42.51%;羟基自由基抑制剂CO_3~(2-)、HCO_3~-和叔丁醇的引入抑制了废水COD的臭氧氧化去除,尤其是叔丁醇的加入使COD去除率显著下降,说明废水中有机物的臭氧氧化去除过程遵循羟基自由基机理;臭氧氧化法对钻井废水中有机物的氧化去除过程符合表观二级反应动力学规律。     

负压蒸发技术处理废弃钻井液

采用负压蒸发技术处理3种不同组分的废弃钻井液。实验结果表明:最佳蒸发温度为79℃;当蒸发温度低于95℃时,相15~#原液的出水氨氮质量浓度、悬浮物质量浓度、色度分别低于3.40 mg/L、0.093 mg/L、11倍,达到GB 8978—1996《污水综合排放标准》中的一级排放标准;当蒸发温度低于79℃时,钻井液1和钻井液2的出水氨氮质量浓度均低于37.00 mg/L,悬浮物质量浓度均低于0.080 mg/L,色度低于13倍,COD低于114.0 mg/L,达到GB 8978—1996《污水综合排放标准》中的二级排放标准。通过后续过滤除油工艺可降低钻井液中的石油类质量浓度,使最终出水达标排放。     

Emerging conservation challenges and prospects in an era of offshore hydrocarbon exploration and exploitation

Globally, extensive marine areas important for biodiversity conservation and ecosystem functioning are undergoing exploration and extraction of oil and natural gas resources. Such operations are expanding to previously inaccessible deep waters and other frontier regions, while conservation‐related legislation and planning is often lacking. Conservation challenges arising from offshore hydrocarbon development are wide‐ranging. These challenges include threats to ecosystems and marine species from oil spills, negative impacts on native biodiversity from invasive species colonizing drilling infrastructure, and increased political conflicts that can delay conservation actions. With mounting offshore operations, conservationists need to urgently consider some possible opportunities that could be leveraged for conservation. Leveraging options, as part of multi‐billion dollar marine hydrocarbon operations, include the use of facilities and costly equipment of the deep and ultra‐deep hydrocarbon industry for deep‐sea conservation research and monitoring and establishing new conservation research, practice, and monitoring funds and environmental offsetting schemes. The conservation community, including conservation scientists, should become more involved in the earliest planning and exploration phases and remain involved throughout the operations so as to influence decision making and promote continuous monitoring of biodiversity and ecosystems. A prompt response by conservation professionals to offshore oil and gas developments can mitigate impacts of future decisions and actions of the industry and governments. New environmental decision support tools can be used to explicitly incorporate the impacts of hydrocarbon operations on biodiversity into marine spatial and conservation plans and thus allow for optimum trade‐offs among multiple objectives, costs, and risks.     

高突矿井大采高工作面瓦斯抽采技术及实践

为解决大采高厚煤层工作面回采期间瓦斯超限难题,应用顶板走向长钻孔中位钻孔和下临近层底板定向长钻孔等瓦斯抽采措施,对回采面瓦斯进行了多源头治理。通过对顶板走向长钻孔的抽采效果考察,确定其垂直层位为40±5 m范围、水平层位为50±10 m范围为最佳瓦斯抽采区域;中位钻孔合理的垂直层位为20 m左右,水平层位为45~50 m范围抽采效果最佳;下临近层底板定向长钻孔是拦截下部5#煤和7#煤向上部采掘空间涌出瓦斯的有效手段,其最佳的水平层位为距巷道轮廓线20 m范围,垂直层位为钻孔布置在下临近层煤层中。通过对3种不同瓦斯治理措施的综合评价考察,确定顶板走向长钻孔是治理回采面最为有效的措施,其抽采量占工作面回采期间总抽采量的79.6%,中位钻孔抽采和下临近层底板定向长钻孔抽采是回采面回采期间的辅助性措施。措施使用后,工作面上隅角瓦斯浓度保持在0.4%~0.6%之间,有效保证了工作面的安全高效回采。     

型煤燃烧固硫的钠离子效应

本文用脉冲二氧化硫荧光分析仪连续测试了煤样中二氧化硫的浓度，并用Ｘ荧光、Ｘ衍射和电子扫描电镜等方法，分析了添加钠离子样品的含硫率、物相及表面形貌。实验结果表明，钠离子添加剂改变了二氧化硫释放过程，抑制了硫酸钙的分解。灰样成分中既有稳定的三元化合物３ＣａＯ．３Ａｌ２Ｏ３．ＣａＳＯ４，也有不稳定的化合物硫酸钙存在，说明钠离子添加剂对提高固硫率有促进作用。